prEN IEC 60335-2-106:2024
(Main)Household and similar electrical appliances - Safety - Part 2-106: Particular requirements for heated carpets and for heating units for room heating installed under removable floor coverings
Household and similar electrical appliances - Safety - Part 2-106: Particular requirements for heated carpets and for heating units for room heating installed under removable floor coverings
This European Standard deals with the safety of - portable heated carpets; - heated carpets and similar appliances; - heating units to heat the room in which they are located and that are intended to be installed directly under materials used as a removable floor covering such as carpet, cushion vinyl, or loose laid laminate, their rated voltage being not more than 250 V for single-phase installations and 480 V for other installations, including direct current (DC) supplied appliances.
Sicherheit elektrischer Geräte für den Hausgebrauch und ähnliche Zwecke - Teil 2-106: Besondere Anforderungen für beheizte Teppiche und für Heizsysteme zur Raumheizung unter abnehmbaren Fußbodenbelägen
Appareils électrodomestiques et analogues - Sécurité - Partie 2-106: Exigences particulières pour les tapis chauffants et les unités chauffantes installées sous des revêtements de sol amovibles, pour le chauffage des locaux
IEC 60335-2-106:2021 est disponible sous forme de IEC 60335-2-106:2021 RLV qui contient la Norme internationale et sa version Redline, illustrant les modifications du contenu technique depuis l'édition précédente. L'IEC 60335-2-106:2021 traite de la sécurité des: - tapis chauffants mobiles; - tapis chauffants et appareils analogues; - unités chauffantes destinées à chauffer la pièce dans laquelle elles sont situées et destinées à être installées directement sous des matériaux utilisés comme un revêtement de sol amovible tel qu'un tapis, un revêtement en vinyle ou un stratifié à pose flottante, dont la tension assignée est inférieure ou égale à 250 V pour les installations monophasées et à 480 V pour les autres installations, y compris les appareils alimentés en courant continu. L'attention est attirée sur le fait que: - dans de nombreux pays, des règles d'installation différentes s'appliquent; - pour les appareils destinés à être utilisés dans des véhicules ou à bord de navires ou d'avions, des exigences supplémentaires peuvent être nécessaires; - dans de nombreux pays, des exigences supplémentaires sont spécifiées par les organismes nationaux responsables de la protection contre l'incendie, par les organismes nationaux responsables des règlements d'installation, par les organismes nationaux de la santé, par les organismes nationaux responsables de la protection des travailleurs et par des organismes similaires. La présente norme ne s'applique pas - aux appareils prévus exclusivement pour des usages industriels; - aux appareils destinés à être utilisés dans des locaux qui présentent des conditions particulières, telles que la présence d'une atmosphère corrosive ou explosive (poussière, vapeur ou gaz); - aux couvertures, coussins, vêtements et appareils chauffants souples analogues (IEC 60335-2-17); - aux chancelières et carpettes chauffantes électriques dont la surface est inférieure ou égale à 0,5 m2 (IEC 60335-2-81); - aux films souples chauffants intégrés au plancher de la structure des bâtiments (IEC 60335-2-96); - aux éléments chauffants souples incorporés dans d'autres appareils; - aux appareils alimentés par batteries. Cette édition inclut les modifications techniques majeures suivantes par rapport à l'édition précédente: a) alignement du texte sur l'IEC 60335-1:2020; b) conversion en texte normatif de certaines notes (Article 1, 5.2, 5.3, 5.6, 7.12.1, 7.101, 10.1, 18.101.1, 18.101.2, 18.102.5, 19.1, 19.103, 21.1, 21.104, 21.105, 30.102); c) ajout d'exigences pour les tapis chauffants mobiles (Article 1, 5.2, 5.5, 6.1, 6.2, 7.1, 7.6, 7.12, 7.14, 7.101, 11.8, 15.1, 15.101, 16.1, 16.2, 16.3, 19.101, 19.102, 19.103, 21.105, 21.106, 24.1.5, 24.2, 29.3); d) ajout d'exigences pour les tapis chauffants mobiles lavables (5.3, 7.1, 7.6, 7.12, 7.14); e) mise à jour de l'essai du 30.102. La présente Partie 2 doit être utilisée conjointement avec la dernière édition de l'IEC 60335-1 et ses amendements, sauf si cette édition l'exclut. Dans ce cas, la dernière édition qui n'exclut pas la présente Partie 2 est utilisée. Elle a été établie sur la base de la sixième édition (2020) de cette norme.
Gospodinjski in podobni električni aparati - Varnost - 2-106. del: Posebne zahteve za grelne preproge in grelne enote za gretje prostorov, nameščene pod odstranljive talne obloge
General Information
Relations
Standards Content (Sample)
SLOVENSKI STANDARD
01-julij-2024
Gospodinjski in podobni električni aparati - Varnost - 2-106. del: Posebne zahteve
za grelne preproge in grelne enote za gretje prostorov, nameščene pod
odstranljive talne obloge
Household and similar electrical appliances - Safety - Part 2-106: Particular requirements
for heated carpets and for heating units for room heating installed under removable floor
coverings
Sicherheit elektrischer Geräte für den Hausgebrauch und ähnliche Zwecke - Teil 2-106:
Besondere Anforderungen für beheizte Teppiche und für Heizsysteme zur Raumheizung
unter abnehmbaren Fußbodenbelägen
Appareils électrodomestiques et analogues - Sécurité - Partie 2-106: Exigences
particulières pour les tapis chauffants et les unités chauffantes installées sous des
revêtements de sol amovibles, pour le chauffage des locaux
Ta slovenski standard je istoveten z: prEN IEC 60335-2-106:2024
ICS:
13.120 Varnost na domu Domestic safety
97.100.10 Električni grelniki Electric heaters
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.
EUROPEAN STANDARD DRAFT
prEN IEC 60335-2-106
NORME EUROPÉENNE
EUROPÄISCHE NORM
May 2024
ICS 13.120; 97.100.10 Will supersede EN 60335-2-106:2007
English Version
Household and similar electrical appliances - Safety - Part 2-106:
Particular requirements for heated carpets and for heating units
for room heating installed under removable floor coverings
(IEC 60335-2-106:2021)
Appareils électrodomestiques et analogues - Sécurité - Sicherheit elektrischer Geräte für den Hausgebrauch und
Partie 2-106: Exigences particulières pour les tapis ähnliche Zwecke - Teil 2-106: Besondere Anforderungen für
chauffants et les unités chauffantes installées sous des beheizte Teppiche und für Heizsysteme zur Raumheizung
revêtements de sol amovibles, pour le chauffage des locaux unter abnehmbaren Fußbodenbelägen
(IEC 60335-2-106:2021) (IEC 60335-2-106:2021)
This draft European Standard is submitted to CENELEC members for enquiry.
Deadline for CENELEC: 2024-08-09.
The text of this draft consists of the text of IEC 60335-2-106:2021.
If this draft becomes a European Standard, CENELEC members are bound to comply with the CEN/CENELEC Internal Regulations which
stipulate the conditions for giving this European Standard the status of a national standard without any alteration.
This draft European Standard was established by CENELEC in three official versions (English, French, German).
A version in any other language made by translation under the responsibility of a CENELEC member into its own language and notified to
the CEN-CENELEC Management Centre has the same status as the official versions.
CENELEC members are the national electrotechnical committees of Austria, Belgium, Bulgaria, Croatia, Cyprus, the Czech Republic,
Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, the
Netherlands, Norway, Poland, Portugal, Republic of North Macedonia, Romania, Serbia, Slovakia, Slovenia, Spain, Sweden, Switzerland,
Türkiye and the United Kingdom.
Recipients of this draft are invited to submit, with their comments, notification of any relevant patent rights of which they are aware and to
provide supporting documentation.
Warning : This document is not a European Standard. It is distributed for review and comments. It is subject to change without notice and
shall not be referred to as a European Standard.
European Committee for Electrotechnical Standardization
Comité Européen de Normalisation Electrotechnique
Europäisches Komitee für Elektrotechnische Normung
CEN-CENELEC Management Centre: Rue de la Science 23, B-1040 Brussels
© 2024 CENELEC All rights of exploitation in any form and by any means reserved worldwide for CENELEC Members.
Project: 78637 Ref. No. prEN IEC 60335-2-106:2024 E
1 European foreword
2 This document (prEN IEC 60335-2-106:2024) consists of the text of IEC 60335-2-106:2021 prepared by
3 IEC/TC 61 "Safety of household and similar electrical appliances".
4 This document is currently submitted to the Enquiry.
5 The following dates are proposed:
• latest date by which the existence of this (doa) dor + 6 months
document has to be announced at national
level
• latest date by which this document has to be (dop) dor + 12 months
implemented at national level by publication of
an identical national standard or by
endorsement
• latest date by which the national standards (dow) dor + 36 months
conflicting with this document have to be (to be confirmed or
withdrawn modified when voting)
6 This document will supersede EN 60335-2-106:2007 and all of its amendments and corrigenda (if any).
IEC 60335-2-106 ®
Edition 2.0 2021-11
INTERNATIONAL
STANDARD
NORME
INTERNATIONALE
colour
inside
Household and similar electrical appliances – Safety –
Part 2-106: Particular requirements for heated carpets and for heating units for
room heating installed under removable floor coverings
Appareils électrodomestiques et analogues – Sécurité –
Partie 2-106: Exigences particulières pour les tapis chauffants et
les unités chauffantes installées sous des revêtements de sol amovibles, pour
le chauffage des locaux
INTERNATIONAL
ELECTROTECHNICAL
COMMISSION
COMMISSION
ELECTROTECHNIQUE
INTERNATIONALE
ICS 13.120; 97.100.10 ISBN 978-2-8322-4142-4
– 2 – IEC 60335-2-106:2021 © IEC 2021
CONTENTS
FOREWORD . 4
INTRODUCTION . 7
1 Scope . 8
2 Normative references . 9
3 Terms and definitions . 9
4 General requirement . 10
5 General conditions for the tests . 10
6 Classification . 11
7 Marking and instructions . 11
8 Protection against access to live parts . 14
9 Starting of motor-operated appliances . 14
10 Power input and current . 14
11 Heating . 15
12 Charging of metal-ion batteries . 16
13 Leakage current and electric strength at operating temperature . 16
14 Transient overvoltages . 17
15 Moisture resistance . 17
16 Leakage current and electric strength . 18
17 Overload protection of transformers and associated circuits . 18
18 Endurance . 18
19 Abnormal operation . 21
20 Stability and mechanical hazards . 23
21 Mechanical strength . 23
22 Construction . 27
23 Internal wiring . 29
24 Components . 29
25 Supply connection and external flexible cords . 29
26 Terminals for external conductors . 30
27 Provision for earthing . 30
28 Screws and connections . 30
29 Clearances, creepage distances and solid insulation . 30
30 Resistance to heat and fire . 31
31 Resistance to rusting . 33
32 Radiation, toxicity and similar hazards . 33
Annexes . 42
Annex B (normative) Battery-operated appliances, separable batteries and detachable
batteries for battery-operated appliances . 43
Bibliography . 44
Figure 101 – Arrangement for testing heating units . 34
Figure 102 – Arrangement for testing heating units to be used only above concrete or
similar floors . 35
IEC 60335-2-106:2021 © IEC 2021 – 3 –
Figure 103 – Arrangement for measuring leakage current and electric strength of the
flexible part . 36
Figure 104 – Jig for locating the contact needle . 37
Figure 105 – Arrangement for the three-thickness fold test . 38
Figure 106 – Equipment for flexing heating elements and internal wiring . 39
Figure 107 – Equipment for the spark ignition test . 40
Figure 108 – Details of the mask . 41
Table 101 – Maximum temperature rises . 16
– 4 – IEC 60335-2-106:2021 © IEC 2021
INTERNATIONAL ELECTROTECHNICAL COMMISSION
____________
HOUSEHOLD AND SIMILAR ELECTRICAL APPLIANCES –
SAFETY –
Part 2-106: Particular requirements for heated carpets and for heating
units for room heating installed under removable floor coverings
FOREWORD
1) The International Electrotechnical Commission (IEC) is a worldwide organization for standardization comprising
all national electrotechnical committees (IEC National Committees). The object of IEC is to promote international
co-operation on all questions concerning standardization in the electrical and electronic fields. To this end and
in addition to other activities, IEC publishes International Standards, Technical Specifications, Technical Reports,
Publicly Available Specifications (PAS) and Guides (hereafter referred to as “IEC Publication(s)”). Their
preparation is entrusted to technical committees; any IEC National Committee interested in the subject dealt with
may participate in this preparatory work. International, governmental and non-governmental organizations liaising
with the IEC also participate in this preparation. IEC collaborates closely with the International Organization for
Standardization (ISO) in accordance with conditions determined by agreement between the two organizations.
2) The formal decisions or agreements of IEC on technical matters express, as nearly as possible, an international
consensus of opinion on the relevant subjects since each technical committee has representation from all
interested IEC National Committees.
3) IEC Publications have the form of recommendations for international use and are accepted by IEC National
Committees in that sense. While all reasonable efforts are made to ensure that the technical content of IEC
Publications is accurate, IEC cannot be held responsible for the way in which they are used or for any
misinterpretation by any end user.
4) In order to promote international uniformity, IEC National Committees undertake to apply IEC Publications
transparently to the maximum extent possible in their national and regional publications. Any divergence between
any IEC Publication and the corresponding national or regional publication shall be clearly indicat
...
Questions, Comments and Discussion
Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.