EN ISO 11890-2:2013
(Main)Paints and varnishes - Determination of volatile organic compound (VOC) content - Part 2: Gas-chromatographic method (ISO 11890-2:2013)
Paints and varnishes - Determination of volatile organic compound (VOC) content - Part 2: Gas-chromatographic method (ISO 11890-2:2013)
ISO 11890-2:2013 is one of a series of standards dealing with the sampling and testing of paints, varnishes and related products.
It specifies a method for the determination of the volatile organic compound (VOC) content of paints, varnishes and their raw materials. This part is preferred if the expected VOC content is greater than 0,1 % by mass and less than about 15 % by mass. When the VOC content is greater than about 15 % by mass, the less complicated method given in ISO 11890‑1 may be used.
This method assumes that the volatile matter is either water or organic. However, other volatile inorganic compounds can be present and might need to be quantified by another suitable method and allowed for in the calculations.
Beschichtungsstoffe - Bestimmung des Gehaltes an flüchtigen organischen Verbindungen (VOC-Gehalt) - Teil 2: Gaschromatographisches Verfahren (ISO 11890-2:2013)
Dieser Teil von ISO 11890 gehört zu einer Reihe von Normen, welche die Probenahme und Prüfung von Beschichtungsstoffen und ähnlichen Produkten behandelt.
Er legt ein Verfahren zum Bestimmen des Gehaltes an flüchtigen organischen Verbindungen (VOC-Gehalt) in Beschichtungsstoffen und deren Rohstoffen fest. Dieser Teil darf angewendet werden, wenn der erwartete VOC-Gehalt über 0,1 % (Massenanteil) und unter 15 % (Massenanteil) liegt. Wenn der VOC-Gehalt über 15 % (Massenanteil) liegt, sollte das weniger komplizierte Verfahren nach ISO 11890-1 angewendet werden.
Dieses Verfahren geht davon aus, dass es sich bei den flüchtigen Anteilen entweder um Wasser oder um organische Verbindungen handelt. Es können jedoch andere flüchtige anorganische Verbindungen anwesend sein, die durch ein anderes geeignetes Verfahren bestimmt und in den Berechnungen berücksichtigt werden dürfen.
Peintures et vernis - Détermination de la teneur en composés organiques volatils (COV) - Partie 2: Méthode par chromatographie en phase gazeuse (ISO 11890-2:2013)
L'ISO 11890-2:2013 fait partie d'une série de normes qui traitent de l'échantillonnage et des essais relatifs aux peintures, vernis et produits assimilés.
Elle spécifie une méthode de détermination de la teneur en composés organiques volatils (COV) des peintures, vernis et de leurs matières premières. Cette méthode est à utiliser de préférence si la teneur escomptée en COV est comprise entre 0,1 % en masse et environ 15 % en masse. Si la teneur en COV est supérieure à environ 15 % en masse, la méthode plus simple préconisée dans l'ISO 11890-1 peut être utilisée.
Cette méthode suppose que la matière volatile est de l'eau ou une matière organique. Toutefois, d'autres composés inorganiques volatils peuvent être présents; il pourrait être nécessaire de les quantifier selon une autre méthode et d'en tenir compte dans les calculs.
Barve in laki - Določevanje hlapnih organskih spojin (VOC) - 2. del: Metoda plinske kromatografije (ISO 11890-2:2013)
General Information
Relations
Standards Content (Sample)
SLOVENSKI STANDARD
01-februar-2014
1DGRPHãþD
SIST EN ISO 11890-2:2007
%DUYHLQODNL'RORþHYDQMHKODSQLKRUJDQVNLKVSRMLQ 92& GHO 0HWRGDSOLQVNH
NURPDWRJUDILMH ,62
Paints and varnishes - Determination of volatile organic compound (VOC) content - Part
2: Gas-chromatographic method (ISO 11890-2:2013)
Beschichtungsstoffe - Bestimmung des Gehaltes an flüchtigen organischen
Verbindungen (VOC-Gehalt) - Teil 2: Gaschromatographisches Verfahren (ISO 11890-
2:2013)
Peintures et vernis - Détermination de la teneur en composés organiques volatils (COV)
- Partie 2: Méthode par chromatographie en phase gazeuse (ISO 11890-2:2013)
Ta slovenski standard je istoveten z: EN ISO 11890-2:2013
ICS:
87.040 Barve in laki Paints and varnishes
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.
EUROPEAN STANDARD
EN ISO 11890-2
NORME EUROPÉENNE
EUROPÄISCHE NORM
March 2013
ICS 87.040 Supersedes EN ISO 11890-2:2006
English Version
Paints and varnishes - Determination of volatile organic
compound (VOC) content - Part 2: Gas-chromatographic
method (ISO 11890-2:2013)
Peintures et vernis - Détermination de la teneur en Beschichtungsstoffe - Bestimmung des Gehaltes an
composés organiques volatils (COV) - Partie 2: Méthode flüchtigen organischen Verbindungen (VOC-Gehalt) - Teil
par chromatographie en phase gazeuse (ISO 11890- 2: Gaschromatographisches Verfahren (ISO 11890-2:2013)
2:2013)
This European Standard was approved by CEN on 28 February 2013.
CEN members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European
Standard the status of a national standard without any alteration. Up-to-date lists and bibliographical references concerning such national
standards may be obtained on application to the CEN-CENELEC Management Centre or to any CEN member.
This European Standard exists in three official versions (English, French, German). A version in any other language made by translation
under the responsibility of a CEN member into its own language and notified to the CEN-CENELEC Management Centre has the same
status as the official versions.
CEN members are the national standards bodies of Austria, Belgium, Bulgaria, Croatia, Cyprus, Czech Republic, Denmark, Estonia,
Finland, Former Yugoslav Republic of Macedonia, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania,
Luxembourg, Malta, Netherlands, Norway, Poland, Portugal, Romania, Slovakia, Slovenia, Spain, Sweden, Switzerland, Turkey and United
Kingdom.
EUROPEAN COMMITTEE FOR STANDARDIZATION
COMITÉ EUROPÉEN DE NORMALISATION
EUROPÄISCHES KOMITEE FÜR NORMUNG
Management Centre: Avenue Marnix 17, B-1000 Brussels
© 2013 CEN All rights of exploitation in any form and by any means reserved Ref. No. EN ISO 11890-2:2013: E
worldwide for CEN national Members.
Contents Page
Foreword .3
Foreword
This document (EN ISO 11890-2:2013) has been prepared by Technical Committee ISO/TC 35 "Paints and
varnishes" in collaboration with Technical Committee CEN/TC 139 “Paints and varnishes” the secretariat of
which is held by DIN.
This European Standard shall be given the status of a national standard, either by publication of an identical
text or by endorsement, at the latest by September 2013, and conflicting national standards shall be
withdrawn at the latest by September 2013.
Attention is drawn to the possibility that some of the elements of this document may be the subject of patent
rights. CEN [and/or CENELEC] shall not be held responsible for identifying any or all such patent rights.
This document supersedes EN ISO 11890-2:2006.
According to the CEN-CENELEC Internal Regulations, the national standards organizations of the following
countries are bound to implement this European Standard: Austria, Belgium, Bulgaria, Croatia, Cyprus, Czech
Republic, Denmark, Estonia, Finland, Former Yugoslav Republic of Macedonia, France, Germany, Greece,
Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal,
Romania, Slovakia, Slovenia, Spain, Sweden, Switzerland, Turkey and the United Kingdom.
Endorsement notice
The text of ISO 11890-2:2013 has been approved by CEN as EN ISO 11890-2:2013 without any modification.
INTERNATIONAL ISO
STANDARD 11890-2
Third edition
2013-03-15
Paints and varnishes —
Determination of volatile organic
compound (VOC) content —
Part 2:
Gas-chromatographic method
Peintures et vernis — Détermination de la teneur en composés
organiques volatils (COV) —
Partie 2: Méthode par chromatographie en phase gazeuse
Reference number
ISO 11890-2:2013(E)
©
ISO 2013
ISO 11890-2:2013(E)
© ISO 2013
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized otherwise in any form
or by any means, electronic or mechanical, including photocopying, or posting on the internet or an intranet, without prior
written permission. Permission can be requested from either ISO at the address below or ISO’s member body in the country of
the requester.
ISO copyright office
Case postale 56 • CH-1211 Geneva 20
Tel. + 41 22 749 01 11
Fax + 41 22 749 09 47
E-mail copyright@iso.org
Web www.iso.org
Published in Switzerland
ii © ISO 2013 – All rights reserved
ISO 11890-2:2013(E)
Contents Page
Foreword .v
1 Scope . 1
2 Normative references . 1
3 Terms and definitions . 1
4 Principle . 2
5 Required supplementary information . 2
6 Apparatus . 2
6.1 Gas chromatograph . 2
6.2 Sample injection system . 3
6.3 Oven . 3
6.4 Detector . 3
6.5 Capillary column. 4
6.6 Qualitative-analysis equipment . 4
6.7 Injection syringe . 4
6.8 Chart recorder . 4
6.9 Integrator . 4
6.10 Sample vials . 4
6.11 Gas filters . 4
6.12 Gases . 4
7 Reagents . 5
7.1 Internal standard . 5
7.2 Calibration compounds . 5
7.3 Dilution solvent . 5
7.4 Marker compound . 5
8 Sampling . 5
9 Procedure. 5
9.1 Density . 5
9.2 Water content . 6
9.3 Gas-chromatographic conditions . 6
9.4 Qualitative analysis of product . 6
9.5 Calibration . 6
9.6 Sample preparation . 7
9.7 Quantitative determination of compound content . 7
10 Calculation . 8
10.1 General . 8
10.2 Method 1: VOC content, as a percentage by mass, of the product “ready for use” . 8
10.3 Method 2: VOC content, in grams per litre, of the product “ready for use” . 9
10.4 Method 3: VOC content, in grams per litre, of the product “ready for use” less water . 9
10.5 Method 4: VOC content, in grams per litre, of the product “ready for use” less water and
less exempt compounds (only required if national legislation applies) .10
11 Expression of results .10
12 Precision .10
12.1 General .10
12.2 Repeatability limit r .
...
Questions, Comments and Discussion
Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.