ASTM D6065-21
(Practice)Standard Practice for Handling, Transportation, and Storage of HFC-227ea 1,1,1,2,3,3,3-Heptafluoropropane (CF3CHFCF3)
Standard Practice for Handling, Transportation, and Storage of HFC-227ea 1,1,1,2,3,3,3-Heptafluoropropane (CF<inf>3</inf>CHFCF<inf>3</inf>)
SIGNIFICANCE AND USE
4.1 This practice provides requirements for the handling, transportation, and storage of HFC-227ea encountered in distribution through both commercial and military channels. It is intended to ensure that HFC-227ea is handled, transported, and stored in such a way that its physical property virtues are not degraded. Transport may be by various means, such as, but not limited to, highway, rail, water, and air.
SCOPE
1.1 This practice covers guidance and direction to suppliers, reclaimers, purchasers, and users in the handling, transportation, and storage of HFC-227ea.
1.2 The values stated in inch-pound units are to be regarded as standard. The values given in parentheses are mathematical conversions to SI units that are provided for information only and are not considered standard.
1.3 This standard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibility of the user of this standard to establish appropriate safety, health, and environmental practices and determine the applicability of regulatory limitations prior to use.
1.4 This international standard was developed in accordance with internationally recognized principles on standardization established in the Decision on Principles for the Development of International Standards, Guides and Recommendations issued by the World Trade Organization Technical Barriers to Trade (TBT) Committee.
General Information
Buy Standard
Standards Content (Sample)
This international standard was developed in accordance with internationally recognized principles on standardization established in the Decision on Principles for the
Development of International Standards, Guides and Recommendations issued by the World Trade Organization Technical Barriers to Trade (TBT) Committee.
Designation: D6065 −21
Standard Practice for
Handling, Transportation, and Storage of HFC-227ea
1
1,1,1,2,3,3,3-Heptafluoropropane (CF CHFCF )
3 3
This standard is issued under the fixed designation D6065; the number immediately following the designation indicates the year of
original adoption or, in the case of revision, the year of last revision. A number in parentheses indicates the year of last reapproval. A
superscript epsilon (´) indicates an editorial change since the last revision or reapproval.
1. Scope P-1 Standard for Safe Handling of Compressed Gases in
Containers
1.1 This practice covers guidance and direction to suppliers,
SB-1 Hazards of Refilling or Reusing Compressed Refriger-
reclaimers, purchasers, and users in the handling,
ant (Halogenated Hydrocarbon) Gas Cylinders
transportation, and storage of HFC-227ea.
SB-5 Hazards of Reusing Disposable Refrigerant (Haloge-
1.2 The values stated in inch-pound units are to be regarded
nated Hydrocarbon) Gas Cylinders
as standard. The values given in parentheses are mathematical
SB-18 Use of Refrigerant (Halogenated Hydrocarbons) Re-
conversions to SI units that are provided for information only
covery Cylinders
and are not considered standard. 4
2.3 U.S. Government Standards:
1.3 This standard does not purport to address all of the 49 CFR Part 172 Hazardous Materials Table, Special
safety concerns, if any, associated with its use. It is the
Provisions, Hazardous Materials Communications, Emer-
responsibility of the user of this standard to establish appro- gency Response Information, Training Requirements, and
priate safety, health, and environmental practices and deter-
Security Plans
mine the applicability of regulatory limitations prior to use. 49 CFR Part 172.101 Purpose and Use of Hazardous Mate-
1.4 This international standard was developed in accor-
rials Table
dance with internationally recognized principles on standard- 49 CFR Part 173 Shippers—General Requirements for Ship-
ization established in the Decision on Principles for the
ments and Packagings
Development of International Standards, Guides and Recom- 49 CFR Part 178 Specifications for Packagings
mendations issued by the World Trade Organization Technical
49 CFR Part 180 Continuing Qualification and Maintenance
Barriers to Trade (TBT) Committee. of Packagings
2. Referenced Documents
3. Terminology
2
2.1 ASTM Standard:
3.1 Definitions of Terms Specific to This Standard:
D6064 Specification for HFC-227ea, 1,1,1,2,3,3,3-
3.1.1 containers, n—storage vessels for HFC-227ea.
Heptafluoropropane (CF CHFCF )
3 3
3.1.2 cylinders, n—containers of HFC-227ea.
3
2.2 CGA Standards:
3.1.3 HFC-227ea, n—1,1,1,2,3,3,3-Heptafluoropropane; a
C-1 Methods for Pressure Testing Compressed Gas Cylin-
compound used to inert or suppress a fire or explosion hazard.
ders
3.1.4 insulated, adj—placed in an isolated situation to pro-
C-6 Standards for Visual Inspection of Steel Compressed
tect and prevent the transfer of damage.
Gas Cylinders
C-7 Guide to Classification and Labeling of Compressed
4. Significance and Use
Gases
4.1 This practice provides requirements for the handling,
transportation, and storage of HFC-227ea encountered in
1
This practice is under the jurisdiction of ASTM Committee D26 on Haloge-
distribution through both commercial and military channels. It
nated Organic Solvents and Fire Extinguishing Agents and is the direct responsi-
bility of Subcommittee D26.09 on Fire Extinguishing Agents.
is intended to ensure that HFC-227ea is handled, transported,
Current edition approved June 1, 2021. Published June 2021. Originally
and stored in such a way that its physical property virtues are
approved in 1996. Last previous edition approved in 2015 as D6065 – 11 (2015).
not degraded. Transport may be by various means, such as, but
DOI: 10.1520/D6065-21.
2
not limited to, highway, rail, water, and air.
For referenced ASTM standards, visit the ASTM website, www.astm.org, or
contact ASTM Customer Service at service@astm.org. For Annual Book of ASTM
Standards volume information, refer to the standard’s Document Summary page on
4
the ASTM website. Code of Federal Regulations (CFR) documents are available from U.S.
3
Available from Compressed GasAssociation, 8484 Westpark Drive, Suite 220, Government Publishing Office (GPO), 732, N. Capitol St., NW, Washington, DC
McLean, VA 22102, http://www.cganet.com. 20401-0001, http://www.gpo.gov.
Copyright © ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959. United States
1
---------------------- Page: 1 ----------------------
D6065 − 21
5. Practice nitrogen to 360 psig (25.8 bar) at 70 °F (21 °C) shall be 72
3 3
lb/ft (1153 kg
...
This document is not an ASTM standard and is intended only to provide the user of an ASTM standard an indication of what changes have been made to the previous version. Because
it may not be technically possible to adequately depict all changes accurately, ASTM recommends that users consult prior editions as appropriate. In all cases only the current version
of the standard as published by ASTM is to be considered the official document.
Designation: D6065 − 11 (Reapproved 2015) D6065 − 21
Standard Practice for
Handling, Transportation, and Storage of HFC-227ea
1
1,1,1,2,3,3,3-Heptafluoropropane (CF CHFCF )
3 3
This standard is issued under the fixed designation D6065; the number immediately following the designation indicates the year of
original adoption or, in the case of revision, the year of last revision. A number in parentheses indicates the year of last reapproval. A
superscript epsilon (´) indicates an editorial change since the last revision or reapproval.
1. Scope
1.1 This practice covers guidance and direction to suppliers, reclaimers, purchasers, and users in the handling, transportation, and
storage of HFC-227ea.
1.2 The values stated in inch-pound units are to be regarded as standard. The values given in parentheses are mathematical
conversions to SI units that are provided for information only and are not considered standard.
1.3 This standard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibility
of the user of this standard to establish appropriate safety safety, health, and healthenvironmental practices and determine the
applicability of regulatory limitations prior to use.
1.4 This international standard was developed in accordance with internationally recognized principles on standardization
established in the Decision on Principles for the Development of International Standards, Guides and Recommendations issued
by the World Trade Organization Technical Barriers to Trade (TBT) Committee.
2. Referenced Documents
2
2.1 ASTM Standards:Standard:
D6064 Specification for HFC-227ea, 1,1,1,2,3,3,3-Heptafluoropropane (CF CHFCF )
3 3
3
2.2 CGA Standards:
C-1 Methods for HydrostaticPressure Testing of Compressed Gas Cylinders
C-6 Standards for Visual Inspection of Steel Compressed Gas Cylinders
C-7 Guide to Preparation of Precautionary Labeling and Marking of Compressed Gas ContainersClassification and Labeling of
Compressed Gases
P-1 Standard for Safe Handling of Compressed Gases in Containers
SB-1 Hazards of Refilling or Reusing Compressed Refrigerant (Halogenated Hydrocarbon) Gas Cylinders
SB-5 Hazards of Reusing Disposable Refrigerant (Halogenated Hydrocarbon) Gas Cylinders
SB-18 Use of Refrigerant (Halogenated Hydrocarbons) Recovery Cylinders
1
This practice is under the jurisdiction of ASTM Committee D26 on Halogenated Organic Solvents and Fire Extinguishing Agents and is the direct responsibility of
Subcommittee D26.09 on Fire Extinguishing Agents.
Current edition approved June 1, 2015June 1, 2021. Published June 2015June 2021. Originally approved in 1996. Last previous edition approved in 20112015 as
D6065 – 11.D6065 – 11 (2015). DOI: 10.1520/D6065-11R15.10.1520/D6065-21.
2
For referenced ASTM standards, visit the ASTM website, www.astm.org, or contact ASTM Customer Service at service@astm.org. For Annual Book of ASTM Standards
volume information, refer to the standard’sstandard’s Document Summary page on the ASTM website.
3
Available from Compressed Gas Association, 14501 George Carter Way, Suite 103, Chantilly VA 20151-1788,8484 Westpark Drive, Suite 220, McLean, VA 22102,
http://www.cganet.com.
Copyright © ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959. United States
1
---------------------- Page: 1 ----------------------
D6065 − 21
4
2.3 U.S. Government Standards:
49 CFR Part 172 Hazardous Materials Table, Special Provisions, Hazardous Materials Communications, Emergency Response
Information, Training Requirements, and Security Plans
Code of Federal Regulations (CFR) Title 40,49 CFR Part 172.101 Part 82.106Purpose and Use of Hazardous Materials Table
Code of Federal Regulations (CFR) Title 49,49 CFR Part 173 Part 173, U.S. Department of Transportation (DOT) Specifications,
Shippers-General Requirements for ShippingShippers—General Requirements for Shipments and Packagings
Code of Federal Regulations (CFR) Title 49,49 CFR Part 178 Part 178, U.S. DOT Specifications, Specifications for Packagings
Code of Federal Regulations (CFR) Title 49,49 CFR Part 180 Part 180, U.S. DOT, Continuing QualificationsContinuing
Qualification and Maintenance of Packagings
3. Terminology
3.1 Definitions of Terms Specific to This Standard:
3.1.1 containers—containers, n—storage vessels for HFC-227ea.
3.1.2 cylinders—cylinders, n—containers of HFC-227ea.
3.1.3 HFC-227ea—HFC-227ea, n—1,1,1,2,3,3,3-Heptafluoropropane; a compound used to inert or suppress a fire or explosion
hazard.
3.1.4 insulated—insulated, adj—placed in a
...
Questions, Comments and Discussion
Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.